2009 Pontiac Solstice
CRM Mitchell1 2021-09-22T22:02:17+00:00
Mileage
32,514
Service Date
9/21/2021
Services Performed
- SEE CHECK ENGINE LIGHT DIAG. CLIENT ADVISED THAT THE TECHNICIAN WAS ABLE TO SECURE GROUND TERMINAL FOR COOLING FAN IN CONNECTOR AND NOW COOLING FANS ARE OPERATING AS PROPERLY DESIGNED AND CHECK ENGINE LIGHT IS NO LONGER PRESENT ON THE DASH – CLIENT ADVISED THAT NO CODES RETURNED – TECHNICIAN PERFORMED OIL CHANGE AS REQUESTED BY CLIENT
- CHECK AND ADVISE : SCANNED VEHICLE FOR CODES AND FOUND : P0480- FAN CONTROL RELAY 1 CIRCUIT OPEN DID NOT ROAD TEST VEHICLE DUE TO OVERHEATING CONCERN. WITH VEHICLE RUNNING IN PARK, FOUND COOLING FAN INOP. MONITORED LIVE DATA WITH SCAN TOOL AND FOUND WITH A/C COMMANDED ON, COOLING FAN DUTY CYCLE COMMAND AT 97% WITH NO OPERATION FROM FAN. BACKPROBED POWER AND GROUND CIRCUITS AT COOLING FAN CONTROL MODULE AND FOUND POWER AND GROUND PRESENT WITH NO FAN OPERATION. REMOVED COOLING FAN CONTROL MODULE AND TESTED VOLTAGE/DUTY CYCLE OUTPUT TO FAN MOTOR AND FOUND GOOD BATTERY VOLTAGE PRESENT WITH DUTY CYCLE MATCHING THAT COMMANDED BY ECM. USING POWER PROBE WITH 30 AMP CIRCUIT BREAKER, APPLIED BATTERY VOLTAGE TO FAN MOTOR DIRECTLY AND FOUND FAN TO OPERATED NORMALLY WITH 10AMP DRAW, WELL WITHIN SPECIFICATIONS. DURING FURTHER INSPECTION, FOUND GROUND TERMINAL ON FAN MOTOR HARNESS BACKED OUT OF CONNECTOR. RE-INSTALLED GROUND TERMINAL INTO CONNECTOR AT FAN CONTROL MODULE. CLEARED CODES AND ROAD TESTED VEHICLE WHILE MONITORING LIVE DATA. ALL OK AT THIS TIME, COOLING FAN AND CONTROL MODULE WORKING AS DESIGNED. NO CODES RETURNED.
- FRONT ____32__ REAR ___32___
- CHECK AND ADVISE CLIENT ADVISED THAT A BG PERFORMANCE OIL SERVICE IS RECOMMENDED BASED OFF OF MILEAGE TO RESTORE THE LIFE OF THE ENGINE – CLIENT APPROVED A REGULAR OIL CHANGE ONLY AT THIS TIME CLIENT ADVISED THAT AN A/C EVACUATION AND RECHARGE IS RECOMMENDED – CLIENT DECLINED A/C SERVICE AT THIS TIME
- Remove and Replace Motor Oil and Oil Filter, Lube Chassis where applicable, Check tire pressure and all Fluid Levels
- FRONT ______ REAR ______
- Hazardous Waste Disposal Fee (Cal)
- PUT LUBE STICKER IN DOOR / RESET MAINTENANCE SYSTEM
- *** RESET MAINT LIGHT
RUDY R. gave our service a 5 star review on 9/21/2021
